Suzuki Forums banner

I am getting a vibration help!

2K views 6 replies 4 participants last post by  KJ2837 
#1 ·
I have been driving my sammi for the last 6 months without a vibration.
Now I was driving home when all of a sudden I started to feel a bad vibration.

I got it home and started to look at the motor and it was clean.

I replaced the motor mounts, and 4 u-joint and now the vibration is between 3 and 4 grand in second gear.

I have tried to line up the drive shaft. I believe I got it.

I am thinking about getting new transfer case mounts but can't figure out where to buy them to get them fast. I have read some posts about a polaris transfer case mounts but can't figure out where to buy them

Its doing it in 2 wheel drive.

Any suggestions. I am staring at this thing and cant figure it out.
 
#4 ·
CJM,


Check the U-Joint up where is comes from the trans. It is a short one up high near the transfer case, but it looks like you got that one, I think. Have you made sure that the front hubs are unlocked? Crawl under try to rotate the front drive shaft, it should spin.

I bet it is the small drive shaft between the trans and t-case. Just move it and see if there is any play. If you already replace some u-joints, you should know what I mean.
 
This is an older thread, you may not receive a response, and could be reviving an old thread. Please consider creating a new thread.
Top